Toyota Yaris Forums - Ultimate Yaris Enthusiast Site
 

 


 
Go Back   Toyota Yaris Forums - Ultimate Yaris Enthusiast Site > Technical Forums > DIY / Maintenance / Service
  The Tire Rack

 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 09-16-2017, 04:18 AM   #1
Kubcat
 
Drives: 2006 and 2013
Join Date: Apr 2013
Location: Sydney Australia
Posts: 7
Hard starting when cold, runs fine

We have a 2006 1.3L automatic Yaris. We are up to 150,000kms. Has run great, no issues at all except a slight hesitation then surge when taking off for the last few years.

I cleaned the throttle body a number of times and replaced spark plugs with no change.

I purchased new injectors and fitted them a couple of weeks ago trying to make it take off smoother but they didn't come with the seals. The old seals were hard and as expected they leaked.

I ordered new seals, refitted the injectors and the care drove a little better, I think, the hesitation/surge is still there but perhaps less.

After about a week though the car has become hard to start when sitting for more than 10 minutes or so. It needs to crank quite a bit, sometimes two goes to start. The car has the auto start feature that once you turn the key even if you let go, it keeps cranking.

It has had hard starting very intermittently in the past, but now it does it every time.

It feels like it is losing fuel pressure when it is switched off. This is confirmed by disconnecting the fuel line that feeds the fuel injector rail, no petrol squirts out like it used to.

If I attempt to start it within a few minutes of turning it off, it starts perfectly.

Except for the slight hesitation/surge, the performance is pretty much how it has always been. It revs cleanly to the redline and idles smoothly.

As I am not seeing any leaks, perhaps it is the injectors leaking or there is something going on in the fuel pump/regulator module in the tank.

Not sure how to check either so I am stuck.

I was going to remove the fuel pump module and replace the filter as it is due in the next 10,000 kms anyway but don't know what to look for in terms of what can be wrong.

I guess I could put the old injectors back in and see if the leak is at that end.

Any ideas on what to do next would be most appreciated.

Last edited by Kubcat; 10-09-2017 at 02:37 AM.
Kubcat is offline   Reply With Quote
 

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
A/C Not Blowing Cold Air...among other things yarisitis DIY / Maintenance / Service 38 07-28-2016 04:00 PM
yaris hard starting when hot, fine when cold ianpog DIY / Maintenance / Service 11 08-12-2015 09:24 PM
chirp/squeak noise just off idle when cold tadc DIY / Maintenance / Service 14 02-20-2011 03:09 PM
Intake Systems Decision Maker.. Blenjar Performance Modifications 25 09-15-2007 10:07 PM
hard starting after moving car gonzo452001 DIY / Maintenance / Service 12 06-09-2007 05:07 PM


All times are GMT -4. The time now is 12:10 PM.




YarisWorld
Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.