Toyota Yaris Forums - Ultimate Yaris Enthusiast Site
 

 


 
Go Back   Toyota Yaris Forums - Ultimate Yaris Enthusiast Site > Technical Forums > DIY / Maintenance / Service
  The Tire Rack

Reply
 
Thread Tools Display Modes
Old 04-24-2017, 05:59 PM   #1
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
Rough Idle/ Stall, Very Hard To Start, Tried usual suggestions

Ok so i am going to admit defeat and ask for help, ive tried everything ive seen on here about trying to fix the idle and nothing has worked. I have replaced the plugs and coils, cleaned the throttle body, cleaned and then replaced the MAF sensor, Cleaned and replaced the air filter, replaced the battery, tried to reset the throttle position using everyones suggestions on how to do it but im still having the same problems, I end up having to crank the car for 10-60seconds while pedaling the gas pedal to get it to start, while the cool light is on the engine runs fine, as soon as the cool light comes off or i drive a little bit the engine will stall as soon as it is out of gear, pressing in the clutch or sitting at a red light. The egine after it stalls is just as hard to crank over i usually end up kick starting it. I have no idea what to do, their are no codes, and no check lights, not even any permenant codes. Any suggestions or help would be greatly appreciated.
rangerkeim is offline   Reply With Quote
Old 04-24-2017, 05:59 PM   #2
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
forgot to mention 2010 toyota yaris sedan stick shift.
rangerkeim is offline   Reply With Quote
Old 04-24-2017, 07:16 PM   #3
Bluevitz-rs
1NZ-6spd
 
Bluevitz-rs's Avatar
 
Drives: '05 6-Spd Vitz RS
Join Date: Oct 2008
Location: Oshawa, Ontario, Canada
Posts: 2,966
Have you checked the fuel system?

Pull the injectors and see if there's any abnormalalities.

Can you check the afr sensor readings?
Bluevitz-rs is offline   Reply With Quote
Old 04-24-2017, 08:04 PM   #4
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
Quote:
Originally Posted by Bluevitz-rs View Post
Have you checked the fuel system?

Pull the injectors and see if there's any abnormalalities.

Can you check the afr sensor readings?

What exactly do I need to check in the fuel system? I have pulled off the fuel line and it delivers fuel while cranking, my obd doesn't have a afr listed on the live data, I havnt pulled the injectors yet but it's on the list of possibilities, problem I am having is 20 solutions to the symptoms but without a code telling me where to look into feel lost. Gonna try to post video of start up and obd2 readings. Rpms hover at 400 once warm. Not very tech savvy it seems gonna upload the videos to you tube and post link

Video 1 https://youtu.be/PPYG15p-IMA starting
Video 2 https://youtu.be/cEmcSt-J5yg obd2

Last edited by rangerkeim; 04-24-2017 at 08:19 PM. Reason: add videos
rangerkeim is offline   Reply With Quote
Old 04-24-2017, 09:15 PM   #5
tmontague
 
tmontague's Avatar
 
Drives: '08 2zr swapped Vios M/T
Join Date: Oct 2012
Location: Caledonia Ont.
Posts: 2,938
does your reader show you O2 voltage? Seems like the car will work in open loop but not closed which is odd
__________________
No one ever wants to give a Yaris the point by...
tmontague is offline   Reply With Quote
Old 04-24-2017, 09:51 PM   #6
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
Quote:
Originally Posted by tmontague View Post
does your reader show you O2 voltage? Seems like the car will work in open loop but not closed which is odd
02b1s1(v) is 3.3
rangerkeim is offline   Reply With Quote
Old 04-24-2017, 10:01 PM   #7
tmontague
 
tmontague's Avatar
 
Drives: '08 2zr swapped Vios M/T
Join Date: Oct 2012
Location: Caledonia Ont.
Posts: 2,938
Does it oscillate or is it only reading 3.3 constant?
__________________
No one ever wants to give a Yaris the point by...
tmontague is offline   Reply With Quote
Old 04-24-2017, 10:02 PM   #8
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
Quote:
Originally Posted by tmontague View Post
Does it oscillate or is it only reading 3.3 constant?
oscillates
rangerkeim is offline   Reply With Quote
Old 04-24-2017, 10:05 PM   #9
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
people have told me timing chain, injectors, fuel pump, camshaft sensor, o2 sensor, ect ect ect and i just dont know where to start, its getting expensive replacing things hoping it will do something
rangerkeim is offline   Reply With Quote
Old 04-24-2017, 10:16 PM   #10
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
is it normal for the fuel pump to only pump fuel when cranking and not when the key is turned on?
rangerkeim is offline   Reply With Quote
Old 04-24-2017, 11:18 PM   #11
Bluevitz-rs
1NZ-6spd
 
Bluevitz-rs's Avatar
 
Drives: '05 6-Spd Vitz RS
Join Date: Oct 2008
Location: Oshawa, Ontario, Canada
Posts: 2,966
Quote:
Originally Posted by rangerkeim View Post
is it normal for the fuel pump to only pump fuel when cranking and not when the key is turned on?
yes.

3.3v is running lean. It should be around 2.5V if your running regular gas.

Try unplugging the AFR sensor and see if your car runs better. If it's still the same, you'll have to check your fuel pressure with an in-line gauge you hook into the fuel line right at the fuel rail. From your description of having to crank for so long and running lean once running, it sounds like you have very low fuel pressure. The pump might have developed an internal leak or the built-in pressure regulator failed.
Bluevitz-rs is offline   Reply With Quote
Old 04-25-2017, 12:04 AM   #12
rangerkeim
 
Drives: 2010 Toyota Yaris
Join Date: Apr 2017
Location: NC
Posts: 8
Quote:
Originally Posted by Bluevitz-rs View Post
yes.

3.3v is running lean. It should be around 2.5V if your running regular gas.

Try unplugging the AFR sensor and see if your car runs better. If it's still the same, you'll have to check your fuel pressure with an in-line gauge you hook into the fuel line right at the fuel rail. From your description of having to crank for so long and running lean once running, it sounds like you have very low fuel pressure. The pump might have developed an internal leak or the built-in pressure regulator failed.
Any idea where the afr sensor is on this model? I've been looking for schematics online but havnt found anything
rangerkeim is offline   Reply With Quote
Old 04-25-2017, 04:33 AM   #13
Bluevitz-rs
1NZ-6spd
 
Bluevitz-rs's Avatar
 
Drives: '05 6-Spd Vitz RS
Join Date: Oct 2008
Location: Oshawa, Ontario, Canada
Posts: 2,966
It's the first sensor in the exhaust coming out of the engine.
Bluevitz-rs is offline   Reply With Quote
Old 04-25-2017, 04:40 AM   #14
ncp13
 
ncp13's Avatar
 
Drives: 01 Yaris TS
Join Date: Jan 2017
Location: Athens Greece
Posts: 92
You have fuel when cranking but how much fuel? Check fuel pressure and check if it holds pressure when you turn it off. (44-50 psi idle) after 5min eng off at least 20psi pressure hold.
Your injectors could be leaking causing rough running and misfires.

You can also check the resistance of the injectors 13-14 Ohms at 20C (68F)

It gets expensinve when you are just replacing stuff. Diagnose first then replace. All the inspections are listed in the repair manuals ask for help and we can get you the information. :)

Good luck !
ncp13 is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Car wont start - help! tamo300 General Yaris / Vitz Discussion 14 03-23-2010 10:44 PM
Yaris does not start jake002 DIY / Maintenance / Service 21 01-05-2010 08:53 AM
Remote Engine Start PT398-33070 Reeves360 In Car Entertainment + Electronics (audio / video / alarm) 3 08-26-2009 07:11 PM
Rough engine start w/76? guyver408 DIY / Maintenance / Service 12 06-26-2009 12:18 AM
Rough Idle in drive toyoman NY / NJ/ CT / PA 8 04-22-2007 03:40 AM


All times are GMT -4. The time now is 05:13 PM.




YarisWorld
Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.