![]() |
![]()
![]() |
![]() |
#109 |
![]() Drives: 2008 Toyota Yaris Join Date: Jul 2016
Location: Crystal Lake, il
Posts: 24
|
Amazon. I should have contacted you first but was trying to be sure to get it in before this trip and it was prime shipping. I've already contacted the seller to see if i can get a replacement for just the stalk since i don't want to pull all the wire out.
The good news is that if the schematics I've seen are correct, the on/off button is just a short to ground with no resistor. Worst case scenario, i mount a momentary switch to the dash and connect it across the leads coming from the back if the steering wheel. By the way, are you still selling the indicator modules? Sent from my LG-H811 using Tapatalk |
![]() |
![]() |
![]() |
#110 |
![]() ![]() ![]() ![]() ![]() ![]() ![]() Drives: 09 5dr LB, 2x 08 3dr LB Join Date: Oct 2008
Location: USA, CT
Posts: 13,460
|
The on/off is just a switch to ground. I would check all of your connection points to make sure it isn't an intermittent connection. If the stalk is one of the Chinese clones, it could be a bad switch within it as well.
I do still sell the indicator modules.
__________________
![]() |
![]() |
![]() |
![]() |
#111 |
![]() Drives: 2008 Toyota Yaris Join Date: Jul 2016
Location: Crystal Lake, il
Posts: 24
|
Yeah, it might just be a bad switch internally. The rest of the functions work fine.
Sent from my LG-H811 using Tapatalk |
![]() |
![]() |
![]() |
#112 |
![]() Drives: 2008 Toyota Yaris Join Date: Jul 2016
Location: Crystal Lake, il
Posts: 24
|
Well, I got a chance to meter the switch finally. Getting 1.5-2 ohms when the on/off button is pressed. Not sure if that's so high that the ECU thinks that it's not ground. I suppose if there's any other resistance such as oxidation on one of the pins between the switch and the ECU it would bump that resistance up and it wouldn't know what to do with it.
|
![]() |
![]() |
![]() |
#113 | |
![]() ![]() ![]() Drives: White '07 3dr LB Join Date: Jun 2016
Location: Montreal
Posts: 480
|
Quote:
I did the readings on my own setup (I used 2x 2-way rocker switch and connecting my ground to the bolt behind the kick panel under the steering wheel) and had a lot of resistance using that ground point compared to the main chassis ground, but still I have flawless operation so far (installed it and been using it daily for 5 days now). However I would really doubt that the switch internal resistance of less than 2 ohms would throw every off. It sounds more like a bad contact inside the ON/OFF switch, otherwise you wouldn't be able to use all the other function flawlessly. |
|
![]() |
![]() |
![]() |
#114 | |
![]() ![]() ![]() ![]() ![]() ![]() ![]() Drives: 09 5dr LB, 2x 08 3dr LB Join Date: Oct 2008
Location: USA, CT
Posts: 13,460
|
Quote:
Was the ECM pin a genuine one that seated properly in the ECM connector?
__________________
![]() |
|
![]() |
![]() |
![]() |
#115 | |
![]() Drives: 2008 Toyota Yaris Join Date: Jul 2016
Location: Crystal Lake, il
Posts: 24
|
Quote:
Sent from my LG-H811 using Tapatalk |
|
![]() |
![]() |
![]() |
#116 | |
![]() ![]() ![]() ![]() ![]() ![]() ![]() Drives: 09 5dr LB, 2x 08 3dr LB Join Date: Oct 2008
Location: USA, CT
Posts: 13,460
|
Quote:
__________________
![]() |
|
![]() |
![]() |
![]() |
#117 | |
![]() Drives: 2008 Toyota Yaris Join Date: Jul 2016
Location: Crystal Lake, il
Posts: 24
|
Quote:
Sent from my LG-H811 using Tapatalk |
|
![]() |
![]() |
![]() |
#118 |
![]() Drives: 2008 Toyota Yaris Join Date: Jul 2016
Location: Crystal Lake, il
Posts: 24
|
Well, I think I figured out what the problem is. I went ahead and pulled the ECM plug back out and checked it out. On closer inspection, the wire that came with the kit does not have the little rubber piece that goes directly behind the pin. This piece not only looks like it seals out moisture, but also locks the pin more securely than the pin lock mechanism does on it's own.
This would explain why it worked flawlessly right after I finished the install because the pin had just been seated. Add on top of that that I didn't have any zip ties for a couple days to re-secure the ECM wires and it was a recipe for that pin to vibrate out slightly. Anyone know what that piece is called? If I can get a picture, I'll post it to show what I'm talking about. Where would I find these? Edit: I found a picture. It's the blue piece right behind the pin on the yellow wire. ![]() Last edited by bassmannate; 08-09-2016 at 10:11 PM. |
![]() |
![]() |
![]() |
#119 |
Winterizing
Drives: 2010 Toyota Yaris Hatchback Join Date: Oct 2011
Location: Pennsylvania
Posts: 157
|
I was looking at this pdf. Looking at the picture of the cruise stalk on page 2, does anyone know if that one wire with the brown connector is actually used?
__________________
33.7 mpg in PA ![]() |
![]() |
![]() |
![]() |
#120 | |
I've made a post!
Drives: 09 Yaris Liftback Join Date: Nov 2016
Location: Utah
Posts: 1
|
![]()
Mr CTScott. I just want to say THANK YOU for taking the time to make this tutorial. Just the fact that its over 6 years old and still being used is a testament to its quality. I just finished installing CC on my 2009 manual 3dr hatchback base. I did go the OEM route and used all Toyota parts for the install. I think it took about 25 mins all said and done. I realize I could have done it cheaper but I just don't like messing with aftermarket parts for stuff like this.
In case anyone is interested here are the Toyota part numbers that I used. 84632-08021 - Cruise Control Assembly - Amazon $84.99 88280-14030 - Cruise Control Clutch Release Switch - Amazon $21.72 45184-52130-B0 - Cover with Cruise Control Hole - ToyotaPartsDeal $23.76 84633-02020 - Cruise Control Switch Wire (with male spade connector for horn) $29.12 I live in the middle of butt hurt nowhere. It's a 90 min drive to Walmart! I cant tell you how happy this makes the wife and I ![]() Thanks! Damien Quote:
|
|
![]() |
![]() |
![]() |
#121 |
I've made a post!
Drives: 2007 Toyota Yaris Join Date: May 2017
Location: Las Vegas USA
Posts: 1
|
IT WORKED GREAT
Well took me a while but i made a video about the install step by step
![]() ![]() Cost me 30 bucks total. I have the most complicated setup in that chart , so i had to install everything here is the video https://www.youtube.com/watch?v=nxRHFkUwg60 Thanks for watching ! ![]() |
![]() |
![]() |
![]() |
#122 |
![]() ![]() ![]() ![]() ![]() Drives: 2014 Yaris SE Join Date: Apr 2014
Location: NYC
Posts: 1,076
|
Thank you for that very well documented step by step video. I'm sure it will help out others in the future.
|
![]() |
![]() |
![]() |
#123 | |
![]() Drives: 2011 Yaris Hatchback 5Dr Join Date: Dec 2012
Location: New Jersey, USA
Posts: 3
|
Quote:
|
|
![]() |
![]() |
![]() |
#124 |
Hubcap Enthusiast
Drives: '09 3-door 5-speed Join Date: Jan 2016
Location: Phoenix
Posts: 272
|
They are M5 screws. Any hardware store will have them. The shortest ones you can find should do fine.
|
![]() |
![]() |
![]() |
#125 | |
![]() Drives: yaris sedan 2011 Join Date: Oct 2016
Location: vietnam
Posts: 19
|
Quote:
can you show me, pin of teminal ECM to connect from Swith CCS? Im a yaris sedan 2014, but i not found pin ECM ( ECU) from my car. OR have you got this Diagram Thanks! |
|
![]() |
![]() |
![]() |
#126 |
![]() Drives: 2010 3 Door L Join Date: Jul 2014
Location: Hot Springs, Arkansas
Posts: 26
|
Just finished my install. Why didn't I do this sooner?!? Thanks for the parts and the great tutorial Scott!
P.S. I didn't order the rear cruise rear boss. I just used this to drill the hole.... https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1 Worked a treat and no pulling the steering wheel!
__________________
"Sanity? What would I do with something as useless as that?” |
![]() |
![]() |
![]() |
|
|
![]() |
||||
Thread | Thread Starter | Forum | Replies | Last Post |
NEWS: TOYOTA REVEALS ALL-NEW YARIS SEDAN AT 2006 LOS ANGELES AUTO SHOW | VitzBoy | General Yaris / Vitz Discussion | 7 | 09-20-2023 07:50 AM |
Cruise Control Available for 06/07 Yaris | TOYOTaejien | General Yaris / Vitz Discussion | 8 | 08-27-2010 12:58 PM |
Cruise Control | chessclubloser | DIY / Maintenance / Service | 11 | 03-27-2010 11:59 AM |
2007 Yaris Pricing Info ! | YarisBueller | New YARIS Purchase Forum | 104 | 06-24-2009 04:54 PM |