Toyota Yaris Forums - Ultimate Yaris Enthusiast Site
 

 


 
Go Back   Toyota Yaris Forums - Ultimate Yaris Enthusiast Site > Technical Forums > DIY / Maintenance / Service
  The Tire Rack

Reply
 
Thread Tools Display Modes
Old 04-06-2015, 08:41 PM   #1
tmontague
 
tmontague's Avatar
 
Drives: '08 2zr swapped Vios M/T
Join Date: Oct 2012
Location: Caledonia Ont.
Posts: 2,938
'02 Echo cooling fan potential problem

I just finished replacing the Tstat, water pump, rad cap, alternator and coolant (rusted part snapped off original alternator so had to replace) and I let it run for a while to burp the air from the system. I then went around the block and let the car sit in the driveway. Nothing is leaking but using my ultragauge I noticed the temp clibed up to 201 F but the fan never kicked on.

What I'm wondering is what is the typical temp that the fan should turn on? I have noticed driving the car a few months ago that it runs about 10F hotter (188-194F)than my Yaris (181-188F) and occasionally it reached 206F temporarily and then dropped down again.

If someone could let me know what the typical trip point is for the fan and if it is not turning on at all then what steps I can take to diagnose the specific problem. I don't want the engine to overheat with summer a few months away. I will be driving it this weekend and will have my gauge in it to monitor how high the temp gets.

Thanks guys
tmontague is offline   Reply With Quote
Old 04-06-2015, 09:11 PM   #2
Jcp123
 
Drives: '00 Echo
Join Date: Mar 2014
Location: E. Tx
Posts: 140
The fan in mine turns on at 206-208*. Kinda strange, at 208 I know it will come on, at 206 sometimes I'll hear it kick in too. Perhaps the signal from the temp sender is read differently by the fan workings than it is by anything plugged into the OBD port.
__________________
Jcp123 is offline   Reply With Quote
Old 04-07-2015, 10:06 AM   #3
tmontague
 
tmontague's Avatar
 
Drives: '08 2zr swapped Vios M/T
Join Date: Oct 2012
Location: Caledonia Ont.
Posts: 2,938
thanks for the input, looks like I just didn't wait long enough for it to turn on. I'll monitor it with my gauge and ensure it turn on around 208F
tmontague is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Worst Cars of the 2000s (#4. Echo) MadMax General Yaris / Vitz Discussion 34 11-12-2009 10:41 AM
Echo and Yaris fan forum jambo101 General Yaris / Vitz Discussion 7 01-26-2009 12:27 PM
Yaris and Echo short shifters sale, $30 off! TWM Performance TWM Performance 8 11-17-2008 02:23 PM
Toyota Echo or Scion Xa/Xb for aftermarket HU receiver kit? ceboyd In Car Entertainment + Electronics (audio / video / alarm) 7 12-08-2006 02:13 PM
what water temp does cooling fan turn on gonzo452001 General Yaris / Vitz Discussion 10 11-07-2006 05:50 AM


All times are GMT -4. The time now is 04:17 AM.




YarisWorld
Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.