Toyota Yaris Forums - Ultimate Yaris Enthusiast Site
 

 


 
Go Back   Toyota Yaris Forums - Ultimate Yaris Enthusiast Site > Technical Forums > DIY / Maintenance / Service
  The Tire Rack

Reply
 
Thread Tools Display Modes
Old 01-04-2018, 05:43 PM   #1
Saphe
 
Drives: Yaris 2010
Join Date: Apr 2015
Location: Sweden
Posts: 6
Fault code P2196 Oxygen sensor?

Hi guys!

Got check engine Light on after diving on a rainy day on the road. Obd reader gives the code P2196.

I have looked around and common issues seems to be the be is; P2196 TOYOTA - Oxygen Air/Fuel Sensor Signal Stuck Rich Bank 1 Sensor 1.

I have searched everywhere to find where the sensor is on the car. Where is bank 1??

I know how to check with multimeter if the sensor is bad but i have first find it to do that :) i believe its connection problems but we will se about that. Does anyone know the location for bank one for my toyota yaris xp9f(a) 2010?

Other common issues for this fault code is:
Faulty Oxygen Air/Fuel Sensor Bank 1 Sensor 1Oxygen Air/Fuel Sensor Bank 1 Sensor 1 harness is open or shortedOxygen Air/Fuel Sensor Bank 1 Sensor 1 circuit poor electrical connectionFaulty EFI RelayFaulty InjectorFaulty Engine Control Module (ECM)

Any other ideas?

PS. A pic showing location would help alot!
Saphe is offline   Reply With Quote
Old 01-05-2018, 09:20 AM   #2
ncp13
 
ncp13's Avatar
 
Drives: 01 Yaris TS
Join Date: Jan 2017
Location: Athens Greece
Posts: 92
Sensor 1 bank 1 is the first sensor before the catalytic converter.
ncp13 is offline   Reply With Quote
Old 01-05-2018, 09:36 AM   #3
Saphe
 
Drives: Yaris 2010
Join Date: Apr 2015
Location: Sweden
Posts: 6
Quote:
Originally Posted by ncp13 View Post
Sensor 1 bank 1 is the first sensor before the catalytic converter.
Oki
Managed to find (see picture) at https://www.toyota-tech.eu/td/td3ewd...wdpath=/td3ewd

at engine compartments. I will se if that helps out locating it.
C73 is connection for bank 1 sensor 1 a/f sensor.
Attached Images
File Type: png 20180105_143232.png (251.5 KB, 56 views)
Saphe is offline   Reply With Quote
Old 01-06-2018, 05:57 PM   #4
SirDigby
 
Drives: 2007 yaris 3 door
Join Date: Sep 2015
Location: Denver, Colorado
Posts: 928
engine exhaust system: you only have a bank 1. if your engine was a V configuration, (V4, V6, V8) you would have bank 1 and bank 2. sensor 1 is before the catalytic converter, (near the engine) sensor 2 is after the catalytic converter.
sensor 1: monitors the engine performance and adjusts fuel injection
sensor 2: monitors catalyst efficenty
i think it sounds like you need to replace sensor. replacement is easy (most of the time)
SirDigby is offline   Reply With Quote
Old 01-07-2018, 03:56 PM   #5
Saphe
 
Drives: Yaris 2010
Join Date: Apr 2015
Location: Sweden
Posts: 6
SirDigiby, thank you for the info. :) :)


I have located it and will test its resistance as soon as possible.

If someone else has problems locating the sensor (for any car) i found a Great Youtube link describing how.

https://youtu.be/vAxuP9UVQPs
How to find o2 sensor locations.
Saphe is offline   Reply With Quote
Old 01-11-2018, 04:35 PM   #6
Saphe
 
Drives: Yaris 2010
Join Date: Apr 2015
Location: Sweden
Posts: 6
Hmm tested my Air fuel sensor (o2) and I have restistance. I cleared the fault code and it came on after 1 1/2 day diving. I had this issue earlier and it seems to be more common that the light goes on when its could Outdoor. +3 or lower so im thinking that the sensor is affected by lower temperature or could something else trigger same fault code?

Im asking do to the Light can be cleared and Everything seems ok untill its getting colder outside :)

Thanks in advance :)
Saphe is offline   Reply With Quote
Old 01-12-2018, 01:12 AM   #7
SirDigby
 
Drives: 2007 yaris 3 door
Join Date: Sep 2015
Location: Denver, Colorado
Posts: 928
that makes sense because the engine runs richer at cold start up. if the air filter was really dirty it might throw a rich fault. an incorrect signal from a dirty MAF sensor may cause a rich condition. a leaking injector could cause fault. this is what i would do:
check condition of air filter. if it is dirty, replace. wile at the auto parts store getting filter, pick up some MAF cleaner. (Mass Air Flow) the MAF is the sensor that is in the air box you remove to change air filter. remove the 2 bolts and pull sensor up. clean with MAF cleaner. allow a few minutes for cleaner to evaporate before reinstalling. i would also replace the A/F sensor. it sounds like it might be lazy. they do wear out. don't buy from the dealership, too expensive. BUT, only buy Denso, (234-9052) Toyota,(89467-52020) or NTK (24661) brands.
SirDigby is offline   Reply With Quote
Old 01-12-2018, 05:53 PM   #8
Saphe
 
Drives: Yaris 2010
Join Date: Apr 2015
Location: Sweden
Posts: 6
Quote:
Originally Posted by SirDigby View Post
that makes sense because the engine runs richer at cold start up. if the air filter was really dirty it might throw a rich fault. an incorrect signal from a dirty MAF sensor may cause a rich condition. a leaking injector could cause fault. this is what i would do:
check condition of air filter. if it is dirty, replace. wile at the auto parts store getting filter, pick up some MAF cleaner. (Mass Air Flow) the MAF is the sensor that is in the air box you remove to change air filter. remove the 2 bolts and pull sensor up. clean with MAF cleaner. allow a few minutes for cleaner to evaporate before reinstalling. i would also replace the A/F sensor. it sounds like it might be lazy. they do wear out. don't buy from the dealership, too expensive. BUT, only buy Denso, (234-9052) Toyota,(89467-52020) or NTK (24661) brands.
Thanks SirDigiby.
I started with cleaning and clearing the sensor connectors with Electric cleaner and this without successivt. No Light came on my way to work (25 km) but driving home did Light it up after 20 minutes of driving :( i dont get any symptoms more then check engine light. My thoughts has also been on looking into the mass Air flow sensor so i will do that and check the air filter. If still the problems occurs then my last step will be buying a new a/f sensor - toyodiy homepage gives me part number 89467-52070
I will se if i find denso in first hand before looking at other producers :)
Thank you for your advice :) i will be putting in the outcome when im done. Will take a while before reposting :)
Saphe is offline   Reply With Quote
Old 01-14-2018, 05:04 PM   #9
SirDigby
 
Drives: 2007 yaris 3 door
Join Date: Sep 2015
Location: Denver, Colorado
Posts: 928
you can not get the Toyota 89467-52070 as it is a discontinued part. (old stock)
the newest, most updated sensor from Toyota is 98467-52020
SirDigby is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
DIY : changing the Oxygen / O2 sensor on Yaris hatch MANY PICS auxmike DIY / Maintenance / Service 46 12-16-2017 08:22 AM
The Official "Bamboo the Yarisworld Traveler" Thread (v4, part 2) Darb Off-topic / Other Cars / Everything else Discussions 86 10-18-2017 08:03 AM
ABS and "!" lights are ON again! onizuka Canada 444 10-04-2017 12:31 PM
The "let's brainstorm how to make a piggyback work" thread eTiMaGo Forced Induction Forum 100 08-17-2011 03:54 PM
NEED ENGINE CHECK LIGHT CODE LIST Attitude Forced Induction Forum 12 04-11-2011 06:38 PM


All times are GMT -4. The time now is 05:58 PM.




YarisWorld
Powered by vBulletin® Version 3.8.0
Copyright ©2000 - 2018, Jelsoft Enterprises Ltd.