COOL Temp Light came back on - Toyota Yaris Forums

captainm27 · 01-09-2014, 04:48 PM

First time it has happened to me. It was so cold this week, that I was actually able to make the COOL light turn back on after it turned off the first time while the engine was still running. I had put my heater on full blast and I believe it sucked all the warmth out of the engine. First time for everything.

IllusionX · 01-09-2014, 05:04 PM

I don't think that's normal. Your thermostat probably doesn't close properly.

Even when the light just turned off (about 50C), putting on max heat should not make the COOL light turn back on, even with -20C temps (-4f)

JustPassinThru · 01-09-2014, 07:13 PM

I've never had it happen; but with another car (Geo Metro) the heater was actually able to pump heat out of the engine to where the gauge would drop back down to the COLD peg.

That was only when it was just warming up. Once the block was thoroughly warmed up, it would hold heat.

Does this happen only when it's just been cold-started? It may be nothing to worry about. You can do a crude test of the thermostat by making this happen and opening the hood - feeling the radiator and cap. If it's warm when the "Cold" light goes on, it's a bad thermostat. If it's not, then you're just sucking heat out of the coolant faster than the block is warming up.

CTScott · 01-09-2014, 07:14 PM

If you catch it right you can make it come back on. I found that out when I was experimenting with overriding the 4th gear prohibition when cold.

Berkut · 01-10-2014, 07:13 AM

Vitz very quickly cools in the winter. And if you turn on the heater to the maximum, heat that the motor is not enough. Thermostats at Toyota ever. The reason is not in it. It is necessary to insulate the engine

captainm27 · 01-10-2014, 09:09 AM

I should have mentioned that the car was idle when this happened. I left it warm up for a few minutes, then turned the heater all the way up and the fan to max and let it idle a bit more. On Tuesday it was really cold here in Northern NJ.

Bluevitz-rs · 01-10-2014, 09:49 AM

It's happened to me before too. I just don't go past ••• on the fan setting. If I go to high before the engine gets up to at least 160F (I have a temp gauge in my car) the engine will start to cool off again. This also eats fuel at a much higher rate. An easy way to make the engine warm up faster is to use the recirculated air mode until you start to steam the windows up.

IllusionX · 01-10-2014, 09:59 AM

That's interesting. cool light supposedly turn off at around 125F ?

I usually turn the fan to max settings once the COOL light turns off, and i've never seen it turn back on. But i'm almost never idling though... so..

Bluevitz-rs · 01-10-2014, 10:30 AM

yeah, if you're driving non stop you're producing a lot of heat. But if you're just in the city the engine isn't and with really cold temps it pulls too much heat from the engine. Remember the heater core does the exact same job as the radiator, except the heat is pulled into the cabin.

Berkut · 01-10-2014, 11:20 AM

Guys, if you have a very cold winter dress warmly, vitz warm car, but he needs a little help, and then it will go up to-50C. I go to sleep but tomorrow will tell all the secrets :)))

01-09-2014, 04:48 PM	#1
captainm27 Drives: 2008 Sedan A/T Silver Join Date: Nov 2008 Location: New Jersey Posts: 202	COOL Temp Light came back on First time it has happened to me. It was so cold this week, that I was actually able to make the COOL light turn back on after it turned off the first time while the engine was still running. I had put my heater on full blast and I believe it sucked all the warmth out of the engine. First time for everything.

01-09-2014, 07:14 PM	#4
CTScott ULTIMATE View User's Garage Drives: 09 5dr LB, 2x 08 3dr LB Join Date: Oct 2008 Location: USA, CT Posts: 13,460	If you catch it right you can make it come back on. I found that out when I was experimenting with overriding the 4th gear prohibition when cold. __________________

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
MAINT REQ'D light question...	SAV912	General Yaris / Vitz Discussion	5	07-29-2010 01:20 AM
Charging System Light	N9QGS	DIY / Maintenance / Service	1	07-26-2010 07:53 PM
Plz help re: LED lights	sleey0	DIY / Maintenance / Service	4	07-23-2010 10:55 PM
cool progressive shift light	cali yaris	Performance Modifications	26	07-26-2009 11:33 PM
test fit 06-07 Yaris 4 door fog light	winson	California	15	01-13-2009 09:25 PM

01-09-2014, 05:04 PM	#2
IllusionX It's the illusion you see View User's Garage Drives: 07 Yaris Sedan Aero Join Date: Oct 2006 Location: Brossard, QC Posts: 3,888	I don't think that's normal. Your thermostat probably doesn't close properly. Even when the light just turned off (about 50C), putting on max heat should not make the COOL light turn back on, even with -20C temps (-4f)

01-09-2014, 07:13 PM	#3
JustPassinThru Drives: No more Yaris Join Date: Dec 2013 Location: Montana Posts: 180	I've never had it happen; but with another car (Geo Metro) the heater was actually able to pump heat out of the engine to where the gauge would drop back down to the COLD peg. That was only when it was just warming up. Once the block was thoroughly warmed up, it would hold heat. Does this happen only when it's just been cold-started? It may be nothing to worry about. You can do a crude test of the thermostat by making this happen and opening the hood - feeling the radiator and cap. If it's warm when the "Cold" light goes on, it's a bad thermostat. If it's not, then you're just sucking heat out of the coolant faster than the block is warming up.

01-10-2014, 07:13 AM	#5
Berkut Drives: Toyota Vitz '05 Join Date: Jun 2010 Location: Russia. Yakutsk Posts: 34	Vitz very quickly cools in the winter. And if you turn on the heater to the maximum, heat that the motor is not enough. Thermostats at Toyota ever. The reason is not in it. It is necessary to insulate the engine

01-10-2014, 09:09 AM	#6
captainm27 Drives: 2008 Sedan A/T Silver Join Date: Nov 2008 Location: New Jersey Posts: 202	I should have mentioned that the car was idle when this happened. I left it warm up for a few minutes, then turned the heater all the way up and the fan to max and let it idle a bit more. On Tuesday it was really cold here in Northern NJ.

01-10-2014, 09:49 AM	#7
Bluevitz-rs 1NZ-6spd View User's Garage Drives: '05 6-Spd Vitz RS Join Date: Oct 2008 Location: Oshawa, Ontario, Canada Posts: 2,967	It's happened to me before too. I just don't go past ••• on the fan setting. If I go to high before the engine gets up to at least 160F (I have a temp gauge in my car) the engine will start to cool off again. This also eats fuel at a much higher rate. An easy way to make the engine warm up faster is to use the recirculated air mode until you start to steam the windows up.

01-10-2014, 09:59 AM	#8
IllusionX It's the illusion you see View User's Garage Drives: 07 Yaris Sedan Aero Join Date: Oct 2006 Location: Brossard, QC Posts: 3,888	That's interesting. cool light supposedly turn off at around 125F ? I usually turn the fan to max settings once the COOL light turns off, and i've never seen it turn back on. But i'm almost never idling though... so..

01-10-2014, 10:30 AM	#9
Bluevitz-rs 1NZ-6spd View User's Garage Drives: '05 6-Spd Vitz RS Join Date: Oct 2008 Location: Oshawa, Ontario, Canada Posts: 2,967	yeah, if you're driving non stop you're producing a lot of heat. But if you're just in the city the engine isn't and with really cold temps it pulls too much heat from the engine. Remember the heater core does the exact same job as the radiator, except the heat is pulled into the cabin.

01-10-2014, 11:20 AM	#10
Berkut Drives: Toyota Vitz '05 Join Date: Jun 2010 Location: Russia. Yakutsk Posts: 34	Guys, if you have a very cold winter dress warmly, vitz warm car, but he needs a little help, and then it will go up to-50C. I go to sleep but tomorrow will tell all the secrets :)))