Toyota Yaris Forums - Ultimate Yaris Enthusiast Site
 

 


 
Go Back   Toyota Yaris Forums - Ultimate Yaris Enthusiast Site > Technical Forums > Forced Induction Forum
  The Tire Rack

Reply
 
Thread Tools Display Modes
Old 12-30-2020, 02:24 AM   #1
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
TA60 carina with 2NZ-FE from yaris + turbox2

in 2013 i fitted 2NZ to my winter beater with itb setup from honda cbr.
It made 100whp.
https://photos.app.goo.gl/oRh8S1gEZ1bndndQ9

2014 summer install turbo, stock internals abou 150whp and made hole in block. Next engine i made fith cp 1NZ na pistons(in 2NZ they give lowwer compression ratio) and autoverdi custom rods. Also add piston cooling jets
https://photos.app.goo.gl/y5jjK2MPzysVcKYy5
https://photos.app.goo.gl/6CRnX6Er83hncWzF8

little mods every year, and last summer finally get 260whp on dyno.

Turbo starting to get little too small and boost doping in hi rpm, so in autumn i made new turbo system.
https://photos.app.goo.gl/1m7NYyNSF6sriuv47

calculated on injector pw engine power was about 360hp

It last about week and this happed
https://photos.app.goo.gl/Xq1V3ysEU1uT5Qgq7
Turbiini is offline   Reply With Quote
Old 12-30-2020, 11:24 AM   #2
lani100
 
lani100's Avatar
 
Drives: Yaris T sport TRD turbo
Join Date: Aug 2017
Location: Netherlands
Posts: 105
Can you share more info on that itb setup?
Also what are you using for management
__________________
2004 Yaris T-Sport
1NZ-FE with TRD Turbo
lani100 is offline   Reply With Quote
Old 12-30-2020, 03:22 PM   #3
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
https://photos.app.goo.gl/FduBGCLGzJ3tkcLj8
https://photos.app.goo.gl/4v1uMGkzedLgTAFFA
i just use prius intake gasket as template aluminium is easy material even hand tools. weld everything, almoust straight pipes.

First i use megasquirt1 lots of self made mods both yaris and cbr injectors was in use.
Later made new intake with single throttle and same time go to migrosquirtmodule with some mods.

using vvt only on off mode, mechanical limiter in actuator to limit max advance.
Turbiini is offline   Reply With Quote
Old 01-01-2021, 04:16 PM   #4
06YarisRS
 
Drives: 06 2ZR Turbo Yaris RS
Join Date: Aug 2017
Location: Fredericton, New Brunswick, Canada
Posts: 2,384
Wow! Very impressive.
__________________


2006 Yaris 5 Door RS 2ZR-FE (2011 Corolla 1.8L) Swapped, Automatic, T-28 Turbocharged (8 psi), HSD MonoPro Coilovers, DIY W/M Injection, custom 3" cold air intake, custom 2.5" exhaust, TRD rear sway bar, Penguin Garage 13mm spacers (rear), custom Civic front lip, full repaint, Android 6.0 7" touchscreen, Rockford Fosgate speakers, tweeters, NVX underseat subwoofer
https://www.instagram.com/2zr_turbo_yarisrs/
06YarisRS is offline   Reply With Quote
Old 02-20-2021, 08:10 AM   #5
06YarisRS
 
Drives: 06 2ZR Turbo Yaris RS
Join Date: Aug 2017
Location: Fredericton, New Brunswick, Canada
Posts: 2,384
Quote:
Originally Posted by Turbiini View Post
in 2013 i fitted 2NZ to my winter beater with itb setup from honda cbr.
It made 100whp.
https://photos.app.goo.gl/oRh8S1gEZ1bndndQ9

2014 summer install turbo, stock internals abou 150whp and made hole in block. Next engine i made fith cp 1NZ na pistons(in 2NZ they give lowwer compression ratio) and autoverdi custom rods. Also add piston cooling jets
https://photos.app.goo.gl/y5jjK2MPzysVcKYy5
https://photos.app.goo.gl/6CRnX6Er83hncWzF8

little mods every year, and last summer finally get 260whp on dyno.

Turbo starting to get little too small and boost doping in hi rpm, so in autumn i made new turbo system.
https://photos.app.goo.gl/1m7NYyNSF6sriuv47

calculated on injector pw engine power was about 360hp

It last about week and this happed
https://photos.app.goo.gl/Xq1V3ysEU1uT5Qgq7
What kind of engine management are you using? Seems like everything is blowing up. Why do you think that is happening? Do you think the melted piston was from a lack of lubrication, or just too much heat? 360 hp is very impressive! Do you have build threads anywhere?
__________________


2006 Yaris 5 Door RS 2ZR-FE (2011 Corolla 1.8L) Swapped, Automatic, T-28 Turbocharged (8 psi), HSD MonoPro Coilovers, DIY W/M Injection, custom 3" cold air intake, custom 2.5" exhaust, TRD rear sway bar, Penguin Garage 13mm spacers (rear), custom Civic front lip, full repaint, Android 6.0 7" touchscreen, Rockford Fosgate speakers, tweeters, NVX underseat subwoofer
https://www.instagram.com/2zr_turbo_yarisrs/
06YarisRS is offline   Reply With Quote
Old 02-20-2021, 09:26 AM   #6
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
i use mifrosquirt module. reason to failure is 2bar boost + 10:1 compression ration + previous litle damages to engine. couple light cratches on cylinder wall causes litle leak and that causes heat to piston. "New" block is ready and waiting pistons. this time lot lower compression ratio.
Turbiini is offline   Reply With Quote
Old 02-20-2021, 10:13 AM   #7
06YarisRS
 
Drives: 06 2ZR Turbo Yaris RS
Join Date: Aug 2017
Location: Fredericton, New Brunswick, Canada
Posts: 2,384
Haha, that is a lot of boost! Can you tell me more about the Mifrosquirt? I've heard of Megasquirt before. I have the AEM F/IC and don't like it. I can't control partial throttle partial boost fueling in closed loop well enough.
__________________


2006 Yaris 5 Door RS 2ZR-FE (2011 Corolla 1.8L) Swapped, Automatic, T-28 Turbocharged (8 psi), HSD MonoPro Coilovers, DIY W/M Injection, custom 3" cold air intake, custom 2.5" exhaust, TRD rear sway bar, Penguin Garage 13mm spacers (rear), custom Civic front lip, full repaint, Android 6.0 7" touchscreen, Rockford Fosgate speakers, tweeters, NVX underseat subwoofer
https://www.instagram.com/2zr_turbo_yarisrs/
06YarisRS is offline   Reply With Quote
Old 02-21-2021, 04:23 AM   #8
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
migrosquirt is based ms2 less options but smaller, migrosquirt module is migrosquirt without casing. only thing wrong is that it can't control vvt-i in closedloop. I use vvt-i only on/off mode and made mechanical limit inside vvt-i actuator.
Turbiini is offline   Reply With Quote
Old 02-26-2021, 04:36 AM   #9
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
https://youtu.be/Gjn59I8kmRE

its running again
Turbiini is offline   Reply With Quote
Old 02-26-2021, 04:59 AM   #10
06YarisRS
 
Drives: 06 2ZR Turbo Yaris RS
Join Date: Aug 2017
Location: Fredericton, New Brunswick, Canada
Posts: 2,384
Quote:
Originally Posted by Turbiini View Post
migrosquirt is based ms2 less options but smaller, migrosquirt module is migrosquirt without casing. only thing wrong is that it can't control vvt-i in closedloop. I use vvt-i only on/off mode and made mechanical limit inside vvt-i actuator.
Thanks for the explanation!
__________________


2006 Yaris 5 Door RS 2ZR-FE (2011 Corolla 1.8L) Swapped, Automatic, T-28 Turbocharged (8 psi), HSD MonoPro Coilovers, DIY W/M Injection, custom 3" cold air intake, custom 2.5" exhaust, TRD rear sway bar, Penguin Garage 13mm spacers (rear), custom Civic front lip, full repaint, Android 6.0 7" touchscreen, Rockford Fosgate speakers, tweeters, NVX underseat subwoofer
https://www.instagram.com/2zr_turbo_yarisrs/
06YarisRS is offline   Reply With Quote
Old 02-28-2021, 04:30 AM   #11
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
https://youtu.be/NRi2GpfH924?t=423
Turbiini is offline   Reply With Quote
Old 03-16-2021, 10:56 PM   #12
.T.
 
Drives: n/a
Join Date: Apr 2020
Location: Australia
Posts: 5
very interested in your rwd conversion - t50 gearbox or w5*? how did you modify the bellhousing or do an adaptor plate?
thanks
.T. is offline   Reply With Quote
Old 03-17-2021, 11:05 AM   #13
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
w58 i weld new mounting plate to bellhousing. new injectors and fuelpump is coming 957cc injectors max out and fuelpump can't keep 4bar basepressure in high boost.

2.4bar is now max boost. Stock yaris clutch pressureplate with cerametallick disk can hold all torque engine is making.
Turbiini is offline   Reply With Quote
Old 03-17-2021, 11:25 AM   #14
Neinris
 
Drives: 08 Yaris 3 Door Hatchback
Join Date: Aug 2019
Location: ‘Murica!
Posts: 446
Subscribed!!!
Neinris is offline   Reply With Quote
Old 05-08-2021, 07:06 AM   #15
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
https://youtu.be/pXTetD8JnJQ
Turbiini is offline   Reply With Quote
Old 09-05-2021, 02:29 AM   #16
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
1/4 mile testing in airfield street tires. speeds is kph.
Attached Images
File Type: jpg IMG_20210905_091153.jpg (112.5 KB, 74 views)
Turbiini is offline   Reply With Quote
Old 08-01-2022, 01:12 AM   #17
Turbiini
 
Drives: 1983 carina 2NZ-FTE
Join Date: Dec 2020
Location: finland
Posts: 34
Ne personal best at 1/8mile
Attached Images
File Type: jpg wcsc22.jpg (81.8 KB, 49 views)
Turbiini is offline   Reply With Quote
Old 08-01-2022, 01:42 AM   #18
sh0rtlife
 
Drives: 2007 5dr canadian import
Join Date: Dec 2016
Location: pacific north WET
Posts: 1,025
hot damn thats fast, especialy for a tiny motor, i loved 8th mile for a time with my 67 barracuda

to be making that kind of power and actualy working it..out of a 1300 is incredibly impressive

i mean i was thrilled to get 400hp NA out of a hybrid 20/22r in a gen1 celica but to be making almost that same power out of 700CC less is astounding
sh0rtlife is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
NEWS: TOYOTA REVEALS ALL-NEW YARIS SEDAN AT 2006 LOS ANGELES AUTO SHOW VitzBoy General Yaris / Vitz Discussion 7 09-20-2023 07:50 AM
DIY Cruise Control FAQ (2006-2010 Yaris) CTScott DIY / Maintenance / Service 467 10-18-2022 10:20 AM
Comparison Test: 2012 Toyota Yaris Vs. 2012 Toyota Prius c Yar Is Word Third Gen Yaris General Discussion 27 09-06-2012 11:37 PM
Vacationed in Italy - Brought home a D4D diesel Yaris CTScott Photo-Video-Media Gallery 19 07-26-2012 03:13 AM
2007 Yaris Pricing Info ! YarisBueller New YARIS Purchase Forum 104 06-24-2009 04:54 PM


All times are GMT -4. The time now is 04:47 PM.




YarisWorld
Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.