HELP PLEEEASE!!! my yaris starts whenever I step on the clutch pedal.

[elcam84]

Originally Posted by CTScott

What's the part number of the relay you have in there now (just to verify that it is the correct relay)?

From there I would check the following:

1. Ignition Switch - Remove the connector from the key switch and with the key off, check continuity between pin 5 (where the gray wire connects to) and pin 7 (where the black wire connects to). Then, move the key to each position and recheck. There should only be continuity between those two pins when the key is held in the start position.


2. While you have that connector off, on the harness side, measure the voltage between the gray wire and the black wire. It should read 12V. If it reads 0V, then there is a short in the wiring. If it reads more than zero, but less than one volt, then the automatic cranking circuit in the ECM is bad. This is the circuit that allows you to just bump the key and then the starter cranks by itself until the car starts. If that is the issue, you can do either of two things - Replace the ECM, or simply eliminate the "bump" starting (which you can do by cutting one wire in the under hood fuse box).

Stepdaughters 08 yaris has started the same symptoms when it's hot. Relay ign switch are good.
Which wire feeds the start relay from the ECM. Need to get it drivable then get a ECM and have it programmed later on.

Thanks